Reduction and oxidation kinetics of nickel-based oxygen-carriers for chemical-looping combustion and chemical-looping reforming

被引：0
|
作者：
机构：
[1] Dueso, Cristina
[2] Ortiz, María
[3] Abad, Alberto
[4] García-Labiano, Francisco
[5] De Diego, Luis F.
[6] Gayán, Pilar
[7] Adánez, Juan
来源：
Adánez, J. (jadanez@icb.csic.es) | 1600年 / Elsevier B.V.卷 / 188期
关键词：
The kinetics of reduction with CH4; H2 and CO and oxidation with O2 of two NiO-based oxygen-carriers for chemical-looping combustion (CLC) and chemical-looping reforming (CLR) prepared by impregnation; NiO18-αAl and NiO21-γAl; have been determined in this work. In both solids; nickel was present as NiO and NiAl2O4 in the oxidized state and the NiO/NiAl2O4 ratio in the particles was a function of the solid conversion reached in the previous reduction process. Both nickel compounds were active for oxygen transfer although with very different reactivities. Therefore; kinetic parameters for NiO and NiAl2O4 reduction were determined for each oxygen carrier and each reacting gas. The reaction rate of NiO reduction was the same in NiO18-αAl and NiO21-γAl particles. A model which assumed a linear relationship between time and conversion was used to describe NiO reduction. Nevertheless; differences in reactivity were observed during NiAl2O4 reduction depending on the type of support; α-Al2O3; or; γ-Al2O3; probably due to a different crystalline structure of the alumina. The changing grain size model for spherical grain geometry was used to obtain the kinetic parameters of the NiAl2O4 reduction working with both NiO-based oxygen-carriers. Chemical reaction control was assumed for NiO18-αAl whereas diffusion through the product layer was also considered when NiO21-γAl was used as oxygen-carrier. The oxidation reaction was very fast with both materials although small differences were observed again between NiO18-αAl and NiO21-γAl oxygen carriers; probably owing to the presence of a higher amount of NiAl2O4 in the solid supported on γ-Al2O3. The combined model for consecutive reduction of NiO and NiAl2O4 in the oxygen-carrier particles with the kinetic parameters obtained in this work predicted adequately the experimental results with both materials. These kinetic data could be used for the design of CLC and CLR systems. © 2012 Elsevier B.V;
D O I：
暂无
中图分类号：
学科分类号：
摘要：
Journal article (JA)
引用
收藏
相关论文
共 50 条
  • [41] Kinetics of redox reactions of ilmenite for chemical-looping combustion
    Abad, Alberto
    Adanez, Juan
    Cuadrat, Ana
    Garcia-Labiano, Francisco
    Gayan, Pilar
    de Diego, Luis F.
    CHEMICAL ENGINEERING SCIENCE, 2011, 66 (04) : 689 - 702
  • [42] Behavior of ilmenite as oxygen carrier in chemical-looping combustion
    Cuadrat, A.
    Abad, A.
    Adanez, J.
    de Diego, L. F.
    Garcia-Labiano, F.
    Gayan, P.
    FUEL PROCESSING TECHNOLOGY, 2012, 94 (01) : 101 - 112
  • [43] A hydrogen and oxygen combined cycle with chemical-looping combustion
    Zhang, Xiaosong
    Li, Sheng
    Hong, Hui
    Jin, Hongguang
    ENERGY CONVERSION AND MANAGEMENT, 2014, 85 : 701 - 708
  • [44] USE OF NATURAL ORES AND WASTE MATERIALS AS OXYGEN CARRIERS FOR CHEMICAL-LOOPING COMBUSTION
    Knutsson, Pavleta
    Schwebel, Georg
    Arjmand, Mehdi
    Leion, Henrik
    Steenari, Britt-Marie
    GEOCONFERENCE ON ENERGY AND CLEAN TECHNOLOGIES, VOL 1 (SGEM 2014), 2014, : 597 - 604
  • [45] Interaction of mineral matter of coal with oxygen carriers in chemical-looping combustion (CLC)
    Keller, Martin
    Arjmand, Mehdi
    Leion, Henrik
    Mattisson, Tobias
    CHEMICAL ENGINEERING RESEARCH & DESIGN, 2014, 92 (09): : 1753 - 1770
  • [46] The use of NiO as an oxygen carrier in chemical-looping combustion
    Mattisson, T
    Johansson, M
    Lyngfelt, A
    FUEL, 2006, 85 (5-6) : 736 - 747
  • [47] The use of ilmenite as an oxygen carrier in chemical-looping combustion
    Leion, Henrik
    Lyngfelt, Anders
    Johansson, Marcus
    Jerndal, Erik
    Mattisson, Tobias
    CHEMICAL ENGINEERING RESEARCH & DESIGN, 2008, 86 (9A): : 1017 - 1026
  • [48] Chemical-looping combustion and chemical-looping reforming of kerosene in a circulating fluidized-bed 300W laboratory reactor
    Moldenhauer, Patrick
    Ryden, Magnus
    Mattisson, Tobias
    Lyngfelt, Anders
    INTERNATIONAL JOURNAL OF GREENHOUSE GAS CONTROL, 2012, 9 : 1 - 9
  • [49] Chemical-Looping Combustion with Liquid Fuels
    Ryden, Magnus
    Moldenhauer, Patrick
    Mattisson, Tobias
    Lyngfelt, Anders
    Younes, Mourad
    Niass, Tidjani
    Fadhel, Bandar
    Ballaguet, Jean-Pierre
    GHGT-11, 2013, 37 : 654 - 661
  • [50] Thermal analysis of chemical-looping combustion
    Jerndal, E.
    Mattisson, T.
    Lyngfelt, A.
    CHEMICAL ENGINEERING RESEARCH & DESIGN, 2006, 84 (A9): : 795 - 806
12345