Reduction and oxidation kinetics of nickel-based oxygen-carriers for chemical-looping combustion and chemical-looping reforming

被引：0
|
作者：
机构：
[1] Dueso, Cristina
[2] Ortiz, María
[3] Abad, Alberto
[4] García-Labiano, Francisco
[5] De Diego, Luis F.
[6] Gayán, Pilar
[7] Adánez, Juan
来源：
Adánez, J. (jadanez@icb.csic.es) | 1600年 / Elsevier B.V.卷 / 188期
关键词：
The kinetics of reduction with CH4; H2 and CO and oxidation with O2 of two NiO-based oxygen-carriers for chemical-looping combustion (CLC) and chemical-looping reforming (CLR) prepared by impregnation; NiO18-αAl and NiO21-γAl; have been determined in this work. In both solids; nickel was present as NiO and NiAl2O4 in the oxidized state and the NiO/NiAl2O4 ratio in the particles was a function of the solid conversion reached in the previous reduction process. Both nickel compounds were active for oxygen transfer although with very different reactivities. Therefore; kinetic parameters for NiO and NiAl2O4 reduction were determined for each oxygen carrier and each reacting gas. The reaction rate of NiO reduction was the same in NiO18-αAl and NiO21-γAl particles. A model which assumed a linear relationship between time and conversion was used to describe NiO reduction. Nevertheless; differences in reactivity were observed during NiAl2O4 reduction depending on the type of support; α-Al2O3; or; γ-Al2O3; probably due to a different crystalline structure of the alumina. The changing grain size model for spherical grain geometry was used to obtain the kinetic parameters of the NiAl2O4 reduction working with both NiO-based oxygen-carriers. Chemical reaction control was assumed for NiO18-αAl whereas diffusion through the product layer was also considered when NiO21-γAl was used as oxygen-carrier. The oxidation reaction was very fast with both materials although small differences were observed again between NiO18-αAl and NiO21-γAl oxygen carriers; probably owing to the presence of a higher amount of NiAl2O4 in the solid supported on γ-Al2O3. The combined model for consecutive reduction of NiO and NiAl2O4 in the oxygen-carrier particles with the kinetic parameters obtained in this work predicted adequately the experimental results with both materials. These kinetic data could be used for the design of CLC and CLR systems. © 2012 Elsevier B.V;
D O I：
暂无
中图分类号：
学科分类号：
摘要：
Journal article (JA)
引用
收藏
相关论文
共 50 条
  • [31] Kinetics of NiO reduction by H2 and Ni oxidation at conditions relevant to chemical-looping combustion and reforming
    Zhou, Zhiquan
    Han, Lu
    Bollas, George M.
    INTERNATIONAL JOURNAL OF HYDROGEN ENERGY, 2014, 39 (16) : 8535 - 8556
  • [32] Sensitivity of chemical-looping combustion to particle reaction kinetics
    Schnellmann, M. A.
    Scott, S. A.
    Williams, G.
    Dennis, J. S.
    CHEMICAL ENGINEERING SCIENCE, 2016, 152 : 21 - 25
  • [33] Innovative Oxygen Carrier Materials for Chemical-Looping Combustion
    Jing, Dazheng
    Mattisson, Tobias
    Ryden, Magnus
    Hallberg, Peter
    Hedayati, Ali
    Van Noyen, Jasper
    Snijkers, Frans
    Lyngfelt, Anders
    GHGT-11, 2013, 37 : 645 - 653
  • [34] Chemical-looping with oxygen uncoupling for combustion of solid fuels
    Mattisson, Tobias
    Lyngfelt, Anders
    Leion, Henrik
    INTERNATIONAL JOURNAL OF GREENHOUSE GAS CONTROL, 2009, 3 (01) : 11 - 19
  • [35] Carbon formation on nickel and iron oxide-containing oxygen carriers for chemical-looping combustion
    Cho, P
    Mattisson, T
    Lyngfelt, A
    INDUSTRIAL & ENGINEERING CHEMISTRY RESEARCH, 2005, 44 (04) : 668 - 676
  • [36] Chemical-Looping Combustion Process: Kinetics and Mathematical Modeling
    Iliuta, Ion
    Tahoces, Raul
    Patience, Gregory S.
    Rifflart, Sebastien
    Luck, Francis
    AICHE JOURNAL, 2010, 56 (04) : 1063 - 1079
  • [37] Solid fuels in chemical-looping combustion
    Leion, Henrik
    Mattisson, Tobias
    Lyngfelt, Anders
    INTERNATIONAL JOURNAL OF GREENHOUSE GAS CONTROL, 2008, 2 (02) : 180 - 193
  • [38] Modelling the reduction of Fe-based oxygen carriers for pressurised chemical-looping combustion of gaseous fuels
    Zhang, Zili
    Yao, Joseph
    Boot-Handford, Matthew
    Scott, Stuart
    Fennell, Paul
    ABSTRACTS OF PAPERS OF THE AMERICAN CHEMICAL SOCIETY, 2015, 250
  • [39] Progress on Chemical-Looping Combustion of Coal
    Mi, Wanliang
    Jia, Dongmei
    2010 THE SECOND CHINA ENERGY SCIENTIST FORUM, VOL 1-3, 2010, : 1020 - +
  • [40] Chemical-looping combustion - a thermodynamic study
    McGlashan, N. R.
    PROCEEDINGS OF THE INSTITUTION OF MECHANICAL ENGINEERS PART C-JOURNAL OF MECHANICAL ENGINEERING SCIENCE, 2008, 222 (06) : 1005 - 1019
12345