Cold plasma processing of powdered Spirulina algae for spore inactivation and preservation of bioactive compounds

被引:46
|
作者
Beyrer, M. [1 ]
Pina-Perez, M. C. [2 ]
Martinet, D. [3 ]
Andlauer, W. [1 ]
机构
[1] Univ Appl Sci & Arts Western Switzerland Valais W, Inst Life Technol, Route Rawil 64, CH-1950 Sion, Switzerland
[2] Univ Valencia, Fac Ciencias Biol, Dept Microbiol & Ecol, C Dr Moliner 50, Valencia 46100, Spain
[3] Univ Appl Sci & Arts Western Switzerland Valais W, Inst Syst Engn, Route Rawil 47, CH-1950 Sion, Switzerland
关键词
Cold plasma; Spirulina; Bacillus spore; carotenoid; Phycobilin; Antioxidant; GAS-PHASE PLASMA; MICROBIAL DECONTAMINATION; ANTIOXIDANT ACTIVITY; CULTIVATION; MICROALGAE; OZONE; LIGHT;
D O I
10.1016/j.foodcont.2020.107378
中图分类号
TS2 [食品工业];
学科分类号
0832 ;
摘要
Technologies for controlling microbial risks in a heat and humidity sensitive food powder are still limited. To preserve bioactive compounds while inactivating Bacillus subtilis spores in powdered Spirulina microalgae (Arthrospira platensis) with a non-thermal atmospheric plasma is the challenge presented in this paper. Artificially contaminated powder was treated with a custom-made surface micro-discharge cold atmospheric pressure plasma (SMD-CAPP) at the effective, specific surface energy of the plasma (Es) of 7-15 mW/cm2. The inactivation of spores in air plasma was faster than in nitrogen plasma. The final effect after 5 min exposure time of close to 2 log10 reduction could be achieved with both plasma types but at different Es. Matrix effects resulted in bi-phasic inactivation kinetics, while single-phasic kinetics were observed for exposure without powder matrix. Chlorophyll-a, carotenoid, and phycobilin concentrations were more reduced by an exposure of the powder to an air plasma, compared to nitrogen plasma. Unexpectedly, the total phenolic content (TPC) increased by a factor of up to 2 at a nitrogen plasma treatment, while a decreasing TPC was observed with increasing plasma (or discharge) energy in an air plasma. Similar effects were identified for the Trolox equivalent antioxidant capacity (TEAC). The liberation of phenolic compounds from biopolymers and the decrease of scavenging compounds by the plasma treatment are supposed being responsible for simultaneous but opposite reactions influencing TPC and TEAC values. Furthermore, the scavenging capacity might reduce the inactivation of spores as observed with the nitrogen versus the air plasma. The failure of a higher spore inactivation relates to structure effects of the powder and improvements are supposed to be reached by a powder fluidization. The application of nitrogen plasma is preferred to that of air plasma for the decontamination of Spirulina powders when the preservation of bioactive compounds is the paramount objective.y
引用
收藏
页数:8
相关论文
共 50 条
  • [31] Impact of atmospheric non-thermal plasma and hydrothermal treatment on bioactive compounds and microbial inactivation of strawberry juice: A hurdle technology approach
    Mehta, Deepak
    Yadav, Sudesh Kumar
    FOOD SCIENCE AND TECHNOLOGY INTERNATIONAL, 2020, 26 (01) : 3 - 10
  • [32] Synergistic Approach to Green Coffee Bean Bioactive Extraction: Integrating Cold Plasma Bubbling and In Situ High-Pressure Processing
    Baskaran, Kamalapreetha
    Radhakrishnan, Mahendran
    IEEE TRANSACTIONS ON PLASMA SCIENCE, 2024, : 1 - 8
  • [33] Optimization of the effect of cold plasma treatment on UAE-NADES green extraction of chickpea roots (Cicer arietinum) bioactive compounds
    Khalid, Waseem
    Benmebarek, Imed E.
    Zargarchi, Sina
    Kumar, Prashant
    Javed, Miral
    Moreno, Andres
    Sharma, Aanchal
    Nayik, Gulzar Ahmad
    Esatbeyoglu, Tuba
    ULTRASONICS SONOCHEMISTRY, 2025, 114
  • [34] The Effect of Cold Plasma Pretreatment on Water-Suspended Herbs Measured in the Content of Bioactive Compounds, Antioxidant Activity, Volatile Compounds and Microbial Count of Final Extracts
    Pogorzelska-Nowicka, Ewelina
    Hanula, Monika Maria
    Brodowska-Trebacz, Marta
    Gorska-Horczyczak, Elzbieta
    Jankiewicz, Urszula
    Mazur, Tomasz
    Marcinkowska-Lesiak, Monika
    Poltorak, Andrzej
    Wierzbicka, Agnieszka
    ANTIOXIDANTS, 2021, 10 (11)
  • [35] Cold plasma: A nonthermal pretreatment, extraction, and solvent activation technique for obtaining bioactive compounds from agro-food industrial biomass
    Gupta, Kishan Kishor
    Routray, Winny
    FOOD CHEMISTRY, 2025, 472
  • [36] Coupling of cold atmospheric plasma treatment with ultrasound-assisted extraction for enhanced recovery of bioactive compounds from cornelian cherry pomace
    Loukri, Anastasia
    Kissas, Thomas
    Kyriakoudi, Anastasia
    Zymvrakaki, Eleni
    Stratakos, Alexandros Ch.
    Mourtzinos, Ioannis
    FOOD CHEMISTRY, 2024, 455
  • [37] Changes of bacterial microbiota and volatile flavor compounds in ewe milk during dielectric barrier discharge cold plasma processing
    Wang, Shuangshuang
    Zhang, Jiaying
    Li, Guowei
    Ding, Yi
    Zhao, Lili
    Song, Yuxuan
    Duan, Xuchang
    Ge, Wupeng
    FOOD RESEARCH INTERNATIONAL, 2022, 159
  • [38] Effect of cold atmospheric plasma pre-treatment and ultrasound-assisted extraction on bioactive compounds and chemical quality of rice bran oil
    Balegh, Sanae Mousapour
    Saadati, Pouya
    Safiaghdam, Mohadeseh
    Fakhari, Ali Asghar
    Razavi, Razie
    LWT-FOOD SCIENCE AND TECHNOLOGY, 2025, 218
  • [39] Design and characterisation of jet cold atmospheric pressure plasma and its effect on Escherichia coli, colour, pH, and bioactive compounds of sour cherry juice
    Hosseini, Seyed Mehdi
    Hosseinzadeh Samani, Bahram
    Rostami, Sajad
    Lorigooini, Zahra
    Gavahian, Mohsen
    Barba, Francisco J.
    INTERNATIONAL JOURNAL OF FOOD SCIENCE AND TECHNOLOGY, 2021, 56 (10): : 4883 - 4892
  • [40] Low soil water content during growth contributes to preservation of green colour and bioactive compounds of cold-stored broccoli (Brassica oleraceae L.) florets
    Cogo, Sarah L. P.
    Chaves, Fabio C.
    Schirmer, Manoel A.
    Zambiazi, Rui C.
    Nora, Leonardo
    Silva, Jorge A.
    Rombaldi, Cesar V.
    POSTHARVEST BIOLOGY AND TECHNOLOGY, 2011, 60 (02) : 158 - 163