Heat transfer enhancement in an air to water heat exchanger with discontinuous helical turbulators; experimental and numerical studies

被引：104
|
作者：
Sheikholeslami, M. [1 ]
Ganji, D. D. [1 ]
机构：
[1] Babol Univ Technol, Dept Mech Engn, Babol Sar, Iran
来源：
ENERGY | 2016年 / 116卷
关键词：
Hydrothermal analysis; Optimization; Helical fin; Heat exchanger; PRESSURE-DROP; FREE-CONVECTION; FLOW; NANOFLUID; PERFORMANCE; BAFFLES; SYSTEM;
D O I：
10.1016/j.energy.2016.09.120
中图分类号：
O414.1 [热力学];
学科分类号：
摘要：
Influence of perforated and typical helical fin on hydrothermal treatment in a water to air heat exchanger is presented. Air and water move through outer and inner pipes, respectively. Effects of pitch ratio (A), Reynolds number (Re-a) and open area ratio (PR) are examined. Empirical formulae for thermal performance (eta), Darcy factor (f) and Nusselt number (Nu) are obtained. NSGA II and ANSYS FLUENT14 are chosen for optimization and numerical simulation. Results indicate that higher open area ratio offers greater thermal performance than the lower one. Temperature gradient attenuates with enhance of open area ratio. (C) 2016 Elsevier Ltd. All rights reserved.
引用
收藏
页码：341 / 352
页数：12
相关论文
共 50 条
  • [31] Numerical and Experimental Investigation for Heat Transfer Enhancement by Dimpled Surface Heat Exchanger in Thermoelectric Generator
    Wang, Yiping
    Li, Shuai
    Yang, Xue
    Deng, Yadong
    Su, Chuqi
    JOURNAL OF ELECTRONIC MATERIALS, 2016, 45 (03) : 1792 - 1802
  • [32] Numerical and Experimental Investigation for Heat Transfer Enhancement by Dimpled Surface Heat Exchanger in Thermoelectric Generator
    Yiping Wang
    Shuai Li
    Xue Yang
    Yadong Deng
    Chuqi Su
    Journal of Electronic Materials, 2016, 45 : 1792 - 1802
  • [33] Experimental and Numerical studies on the Heat transfer characteristics of Small Shell and Tube Heat Exchanger
    Khatawate, Vinayak P.
    Banapurmath, N. R.
    Hosmath, R. S.
    Sanjeevannavar, Mallesh B.
    Golabhanvi, Shailesh M.
    MATERIALS TODAY-PROCEEDINGS, 2022, 59 : 1163 - 1167
  • [34] Experimental analysis for heat transfer of nanofluid with wire coil turbulators in a concentric tube heat exchanger
    Akyurek, Eda Feyza
    Gelis, Kadir
    Sahin, Bayram
    Manay, Eyuphan
    RESULTS IN PHYSICS, 2018, 9 : 376 - 389
  • [35] Enhancement of heat transfer in a vertical shell and tube heat exchanger using air injection and new baffles: Experimental and numerical approach
    Al-darraji, Ahmed Rahmah
    Marzouk, S. A.
    Aljabr, Ahmad
    Almehmadi, Fahad Awjah
    Alqaed, Saeed
    Kaood, Amr
    APPLIED THERMAL ENGINEERING, 2024, 236
  • [36] Experimental and numerical study to optimize flow and heat transfer of airfoil-shaped turbulators in a double-pipe heat exchanger
    Mousavi, Seyed Mahdi Seyed
    Alavi, Seyed Mahmoud Abolhasan
    APPLIED THERMAL ENGINEERING, 2022, 215
  • [37] Investigation of Inclined Turbulators for Heat Transfer Enhancement in a Solar Air Heater
    Bhattacharyya, Suvanjan
    Chattopadhyay, Himadri
    Guin, Anindya
    Benim, Ali Cemal
    HEAT TRANSFER ENGINEERING, 2019, 40 (17-18) : 1451 - 1460
  • [38] Heat transfer characteristics of a helical heat exchanger
    San, Jung-Yang
    Hsu, Chih-Hsiang
    Chen, Shih-Hao
    APPLIED THERMAL ENGINEERING, 2012, 39 : 114 - 120
  • [39] Numerical research on heat transfer enhancement of shutter baffle heat exchanger
    Gu, Xin
    Dong, Qi-Wu
    Liu, Min-Shan
    Zhou, Ya-Ning
    Gao Xiao Hua Xue Gong Cheng Xue Bao/Journal of Chemical Engineering of Chinese Universities, 2010, 24 (02): : 340 - 345
  • [40] Numerical investigation on the nanofluid heat transfer enhancement in ground heat exchanger
    Liu, Qinggong
    Lv, Chao
    Wen, Minjie
    Wang, Yong
    RENEWABLE ENERGY, 2025, 244
12345