Use of kaolin waste for the production of cement bricks

被引：0

作者：

Rezende, Maria Luiza de S. ^{[1
]}

Menezes, Romualdo R. ^{[2
]}

Neves, Gelmires de Araujo ^{[2
]}

Nascimento, Jose Wallace B. ^{[3
]}

Leal, Antonio Farias ^{[3
]}

机构：

[1] UFCG, COPEAG, Campinas, Brazil

[2] UFCG, Unidade Acad Eng Mat, Campinas, Brazil

[3] UFCG, Unidade Acad Eng Agricola, Campinas, Brazil

来源：

REM-REVISTA ESCOLA DE MINAS | 2008年 / 61卷 / 03期

关键词：

Recycling; kaolin waste; masonry block;

D O I：

暂无

中图分类号：

学科分类号：

摘要：

Kaolin is a clay used in several industrial applications, however its production generates large amount of waste. Thus, the aim of this work is estimate the amount of kaolin production waste accumulated in the production region of the Paraiba state,Brazil, and evaluate its suitability as an alternative raw material for the production of masonry blocks without structural function. The waste was classified according to environmental laws, and characterized by chemical composition and physical characteristics determination. Satellite images were used to estimate the amount Of accumulated waste. Cement-sand masonry blocks were prepared partially substituting sand by kaolin waste and their compression strength and water absorption were determined. The waste was classified as non-dangerous but non-inert material, and the estimated amount of accumulated waste was higher than 2.6 millions tons. Sand can be partially substituted for kaolin waste in amounts of tip to 70% in the production of masonry blocks.

引用

页码：285 / 290

页数：6

共 50 条

[41] Life cycle assessment of beneficial use of domestic waste for cement production in China
Liu, Y.
Cui, J.
Cui, S.
Gong, X.
Wang, Z.
MATERIALS RESEARCH INNOVATIONS, 2014, 18 : 62 - 66
[42] The Use of Cement Production Waste to Improve the Properties of Hot Mix Asphalt Concrete
Abed, Adil
Eyada, Saadoon
JORDAN JOURNAL OF CIVIL ENGINEERING, 2019, 13 (03) : 394 - 404
[43] Environment low-impact cement produced from Amazon kaolin waste
Arruda Junior, Euler Santos
Barata, Marcio Santos
MATERIA-RIO DE JANEIRO, 2022, 27 (01):
[44] EVALUATION OF GRITS AS THE BUILDING MATERIALS IN THE PRODUCTION OF SOIL-CEMENT BRICKS
Miranda, Larissa de Almeida
Silva Sant'Anna Alvarenga, Rita de Cassia
Moreira Pinto Junior, Paulo Cesar
de Paula Junior, Eduardo Dantas
Braz de Carvalho, Carlos Alexandre
Fassoni, Delio Porto
Couto, Lauro Gontijo
REVISTA ARVORE, 2011, 35 (06): : 1335 - 1340
[45] Recycling of sugarcane bagasse ash waste in the production of clay bricks
Faria, K. C. P.
Gurgel, R. F.
Holanda, J. N. F.
JOURNAL OF ENVIRONMENTAL MANAGEMENT, 2012, 101 : 7 - 12
[46] Utilization of aluminum plant's waste for production of insulation bricks
Mandal, Arup Kumar
Verma, Himanshu Ranjan
Sinha, O. P.
JOURNAL OF CLEANER PRODUCTION, 2017, 162 : 949 - 957
[47] NEW TECHNOLOGIES IN THE PRODUCTION OF BRICK Ecological bricks from waste
Oreskovic, Lidija
GRADEVINAR, 2016, 68 (11): : 937 - 941
[48] Refractory Behaviors of Magnetite-Kaolin Bricks
Adeosun, S. O.
Akpan, E. I.
Gbenebor, O. P.
Taiwo, O. O.
Eke, I. J.
JOM, 2016, 68 (11) : 2824 - 2831
[49] Energy efficient production of clay bricks using industrial waste
Lissy, Mary P. N.
Peter, Carolin
Mohan, Kavya
Greens, Shone
George, Sneha
HELIYON, 2018, 4 (10):
[50] Reusing plastic waste in the production of bricks and paving blocks: a review
Uvarajan, Turkeswari
Gani, Paran
Chuan, Ng Chuck
Zulkernain, Nur Hanis
EUROPEAN JOURNAL OF ENVIRONMENTAL AND CIVIL ENGINEERING, 2022, 26 (14) : 6941 - 6974

← 1 2 3 4 5 →