Effect of MgO on microstructure evolution and exothermic characteristics of tricalcium aluminate during hydration

被引：1
|
作者：
Li, Shuai [1 ]
Wei, Yaowu [1 ,2 ]
Li, Bingrong [1 ]
Wang, Xiujuan [1 ]
Chen, Junfeng [1 ]
机构：
[1] Wuhan Univ Sci & Technol, State Key Lab Refractories & Met, Wuhan 430081, Peoples R China
[2] 947 Heping Rd, Wuhan 430081, Hubei, Peoples R China
来源：
CERAMICS INTERNATIONAL | 2024年 / 50卷 / 01期
关键词：
Tricalcium aluminate; Magnesium oxide; Microstructure evolution; Exothermic characteristics; CRYSTAL-STRUCTURE; CAO GRANULES; RESISTANCE; IMPROVEMENT; CARBONATION; AMMONIUM;
D O I：
10.1016/j.ceramint.2023.10.313
中图分类号：
TQ174 [陶瓷工业]; TB3 [工程材料学];
学科分类号：
0805 ; 080502 ;
摘要：
The phase composition, microstructure, and hydration process of C3A with different MgO content were compared to elucidate the mechanism of hydration resistance of CaO improved by MgO-C3A solid solution. The process of hydration heat release was detected by isothermal calorimetry and the hydration products were analyzed by X-ray diffraction and scanning electron microscope. The results showed that the addition of MgO resulted in lattice distortion of C3A. In the middle and late stages of the hydration process, Mg(OH)2 and amorphous gel-like substances covered the surface of the unreacted C3A and reduced the hydration reaction rate. The addition of MgO effectively reduced the hydration activity of the MgO-C3A solid solution that indicated the addition of MgO can improve the hydration resistance of CaO materials.
引用
收藏
页码：2055 / 2061
页数：7
相关论文
共 50 条
  • [41] Hydration characteristics and hydration products of tricalcium silicate doped with a combination of MgO, Al2O3 and Fe2O3
    Stephan, Dietmar
    Dikoundou, Sophie Njooh
    Raudaschl-Sieber, Gabriele
    THERMOCHIMICA ACTA, 2008, 472 (1-2) : 64 - 73
  • [42] COMBINED EFFECT OF LIGNOSULFONATE AND CARBONATE ON PURE PORTLAND CLINKER COMPOUNDS HYDRATION .4. HYDRATION OF TRICALCIUM ALUMINATE-SODIUM OXIDE SOLID-SOLUTION
    PAURI, M
    FERRARI, G
    COLLEPARDI, M
    CEMENT AND CONCRETE RESEARCH, 1983, 13 (01) : 61 - 68
  • [43] Comparison of the effect of ground waste expanded perlite and silica fume on the hydration of cements with various tricalcium aluminate content - Comprehensive analysis
    Kapeluszna, Ewa
    Kotwica, Lukasz
    Nocun-Wczelik, Wieslawa
    CONSTRUCTION AND BUILDING MATERIALS, 2021, 303
  • [44] New Approach to the Hydration Reaction of the Tricalcium Aluminate with Gypsum at 30 degree C. Part I: Effect of Lime.
    Ghorab, H.Y.
    Abou El Fetouh, S.H.
    Zement-Kalk-Gips, Edition B, 1985, 38 (05): : 267 - 270
  • [45] Three-dimensional imaging of cement microstructure evolution during hydration
    Helfen, L
    Dehn, E
    Mikulík, P
    Baumbach, T
    ADVANCES IN CEMENT RESEARCH, 2005, 17 (03) : 103 - 111
  • [46] A NEW APPROACH TO THE HYDRATION REACTION OF THE TRICALCIUM ALUMINATE WITH GYPSUM AT 30-DEGREES-C .2. EFFECT OF ALKALI IN PRESENCE OF LIME
    GHORAB, HY
    ELFETOUH, SHA
    ZEMENT-KALK-GIPS, 1985, 38 (06): : 332 - 334
  • [47] Hydration characteristics of portland cement after heat curing: II, evolution of crystalline aluminate-bearing hydrates
    Yang, RH
    Sharp, JH
    JOURNAL OF THE AMERICAN CERAMIC SOCIETY, 2001, 84 (05) : 1113 - 1119
  • [48] Influence of metakaolin on the hydration and microstructure evolution of cement paste during the early stage
    Li, Wei
    Hua, Liangmao
    Shi, Yulei
    Wang, Penggang
    Liu, Zhicheng
    Cui, Dongbo
    Sun, Xiaoguang
    APPLIED CLAY SCIENCE, 2022, 229
  • [49] Effect of Microstructure Changes Caused by Cold Rolling on the Exothermic Characteristics of Al/Ni Multilayer Material
    Yamashita, Souto
    Saegusa, Hiroya
    Namazu, Takahiro
    Miyake, Shugo
    SENSORS AND MATERIALS, 2024, 36 (08) : 3433 - 3444
  • [50] Hydration characteristics and microstructure evolution of concrete with blended binders from LCD and OLED wastes
    Yang, Hee Jun
    Lee, Hyeongi
    Wang, Lei
    Hanif, Asad
    EUROPEAN JOURNAL OF ENVIRONMENTAL AND CIVIL ENGINEERING, 2023, 27 (01) : 174 - 193
12345