Study on calculation method of condensation heat transfer for non-azeotropic hydrocarbon mixtures in helically coiled tubes

被引：0
|
作者：
Jiawen Yu
Xiaojun Li
Yi Li
Yue Wang
机构：
[1] Zhejiang Sci-Tech University,National
[2] Northeast Electronic Power University,Provincial Joint Engineering Laboratory for Fluid Transmission System Technology
来源：
Journal of Thermal Analysis and Calorimetry | 2020年 / 141卷
关键词：
Zeotropic mixtures; Condensation; Hydrocarbon refrigerant; Heat transfer; Helical tube; Numerical simulation;
D O I：
暂无
中图分类号：
学科分类号：
摘要：
In order to study the condensation heat transfer characteristics of non-azeotropic hydrocarbon mixtures in helically coiled tubes for large-scale spiral-wound heat exchangers, a simplified physical model of three-section helical tubes was proposed. Reasonable governing equations and boundary conditions were set up, and the grid independence was verified. Then, the condensation heat transfer characteristics of mixture refrigerants were analyzed. In addition, considering the effect of mass transfer resistance of non-azeotropic mixtures on heat transfer during condensation, a method combining numerical simulation with the Bell and Ghaly correction method was proposed to calculate the condensation heat transfer coefficient of mixtures. By comparing with the experimental results, the accuracy of the calculation model is verified, which provides theoretical support for the design of large-scale spiral-wound heat exchangers.
引用
收藏
页码：177 / 186
页数：9
相关论文
共 50 条
  • [1] Study on calculation method of condensation heat transfer for non-azeotropic hydrocarbon mixtures in helically coiled tubes
    Yu, Jiawen
    Li, Xiaojun
    Li, Yi
    Wang, Yue
    JOURNAL OF THERMAL ANALYSIS AND CALORIMETRY, 2020, 141 (01) : 177 - 186
  • [2] Heat transfer degradation during condensation of non-azeotropic mixtures
    Azzolin, M.
    Berto, A.
    Bortolin, S.
    Del Col, D.
    35TH UIT HEAT TRANSFER CONFERENCE (UIT2017), 2017, 923
  • [3] Forced convective condensation flow and heat transfer characteristics of hydrocarbon mixtures refrigerant in helically coiled tubes
    Yu, Jiawen
    Jiang, Yiqiang
    Cai, Weihua
    Li, Fengzhi
    INTERNATIONAL JOURNAL OF HEAT AND MASS TRANSFER, 2018, 124 : 646 - 654
  • [4] Peculiarities of determination of the heat transfer coefficient at boiling of non-azeotropic mixtures in tubes
    Mezentseva, N. N.
    Mezentsev, I., V
    ALL-RUSSIAN CONFERENCE XXXIV SIBERIAN THERMOPHYSICAL SEMINAR, DEDICATED TO THE 85TH ANNIVERSARY OF ACADEMICIAN A. K. REBROV, 2018, 1105
  • [5] Heat transfer at nucleate boiling of non-azeotropic mixtures
    Mezentseva, N. N.
    Mukhin, V. A.
    Mezentsev, I. V.
    INTERNATIONAL CONFERENCE PROBLEMS OF THERMAL PHYSICS AND POWER ENGINEERING (PTPPE-2017), 2017, 891
  • [6] Condensation flow patterns and heat transfer correction for zeotropic hydrocarbon mixtures in a helically coiled tube
    Yu, Jiawen
    Jiang, Yiqiang
    Cai, Weihua
    Li, Xiaojun
    Zhu, Zuchao
    INTERNATIONAL JOURNAL OF HEAT AND MASS TRANSFER, 2019, 143
  • [7] Prediction method for evaporation heat transfer of non-azeotropic refrigerant mixtures flowing inside internally grooved tubes
    Zhang, Xiayan
    Ji, Changfa
    Yuan, Xiuling
    APPLIED THERMAL ENGINEERING, 2008, 28 (14-15) : 1974 - 1983
  • [8] Experimental study of condensation heat transfer of R-404A in helically coiled tubes
    Salimpour, Mohammad Reza
    Shahmoradi, Ali
    Khoeini, Davood
    INTERNATIONAL JOURNAL OF REFRIGERATION-REVUE INTERNATIONALE DU FROID, 2017, 74 : 584 - 591
  • [9] Experimental investigation of the heat transfer behaviors of CO2, propane and their binary non-azeotropic mixtures above critical pressure in helically coiled tube
    Zhang, Shijie
    Xu, Xiaoxiao
    Liu, Chao
    Wu, Chuang
    Sun, Pengfei
    Dang, Chaobin
    APPLIED THERMAL ENGINEERING, 2020, 180
  • [10] Condensation heat transfer of a non-azeotropic binary mixture on a horizontal tube
    Tsinghua Univ, Beijing, China
    Int J Heat Mass Transfer, 2 (233-240):
12345