Effects of thermal annealing on variations of electron traps in the channel region of amorphous In-Ga-Zn-O thin film transistor

Photoinduced transient spectroscopy (PITS) was applied to study the effects of thermal annealing in the thin-film transistor (TFT) fabrication process on the variations of the electron traps in the channel region of amorphous In-Ga-Zn-O (a-IGZO). A dominant peak with a maximum of around 130K was observed in the PITS spectra, but the detailed features were varied depending on the annealing conditions. The six particular temperatures corresponding to the trap states were extracted at about 100, 140, 150, 210, 320, and 390K from the differential PITS spectra, showing good correlation with the trap states observed in ZnO. The results of thermal desorption spectrometry suggested that the variation of electron traps in the a-IGZO thin films has its origin in the decomposition of O and Zn during the annealing process. The annealing after the etch-stop layer deposition was also examined. The peak at about 150K extracted from the differential PITS spectra before and after the annealing was markedly decreased. The activation energy of the corresponding trap states was estimated to be around 0.3 eV, which was close to those known as the E3 center in ZnO. Secondary ion mass spectroscopy analysis suggested that the reduction of trap density was mainly due to a decrease in the number of defects which involve hydrogen atoms in their configuration. Considering these results, the variations in the electron traps in the a-IGZO thin films during the TFT fabrication process should be attributed to the introduction of Zn, O, and/or H-related defects into tetrahedra consisting of Zn-O bonds. (C) 2014 American Vacuum Society.