Bioplastic recovery from wastewater: A new protocol for polyhydroxyalkanoates (PHA) extraction from mixed microbial cultures

被引：111

作者：

Mannina, Giorgio ^{[1
]}

Presti, Dario ^{[1
]}

Montiel-Jarillo, Gabriela ^{[2
]}

Eugenia Suarez-Ojeda, Maria ^{[2
]}

机构：

[1] Univ Palermo, Dipartimento Ingn, Viale Sci,Ed 8, Palermo, Italy

[2] Univ Autonoma Barcelona, Dept Chem Biol & Environm Engn, GENOCOV Res Grp, Sch Engn,Escola Engn, Edifici Q Campus UAB, E-08193 Barcelona, Spain

来源：

BIORESOURCE TECHNOLOGY | 2019年 / 282卷

关键词：

Bioplastic; Water resource recovery; PHA; Wastewater treatment; POLY(3-HYDROXYBUTYRATE) PRODUCTION; MICROSTRUCTURE; PERFORMANCE; ENRICHMENT; EFFICIENT; BIOMASS;

D O I：

10.1016/j.biortech.2019.03.037

中图分类号：

S2 [农业工程];

学科分类号：

0828 ;

摘要：

A new protocol for polyhydroxyalkanoates (PHA) extraction from mixed microbial cultures (MMCs) is proposed. PHA-accumulating capacity of the MMC was selected in a sequencing batch reactor (SBR) fed with a synthetic effluent emulating a fermented oil mill wastewater (OMW). The highest recovery yield and purity (74 +/- 8% and 100 +/- 5%, respectively) was obtained when using NH4-Laurate for which operating conditions of the extraction process such as temperature, concentration and contact time were optimized. Best conditions for PHA extraction from MMC turned to be: i) a pre-treatment with NaClO at 85 degrees C with 1 h of contact time, followed by ii) a treatment with lauric acid in a ratio acid lauric to biomass of 2:1 and 3 h of contact time.

引用

页码：361 / 369

页数：9

共 50 条

[1] Extraction of polyhydroxyalkanoates from mixed microbial cultures: Impact on polymer quality and recovery
Samori, Chiara
Abbondanzi, Federica
Galletti, Paola
Giorgini, Loris
Mazzocchetti, Laura
Torri, Cristian
Tagliavini, Emilio
BIORESOURCE TECHNOLOGY, 2015, 189 : 195 - 202
[2] Recovery of Polyhydroxyalkanoates From Single and Mixed Microbial Cultures: A Review
Pagliano, Giorgia
Galletti, Paola
Samori, Chiara
Zaghini, Agnese
Torri, Cristian
FRONTIERS IN BIOENGINEERING AND BIOTECHNOLOGY, 2021, 9
[3] Novel alternative recovery of polyhydroxyalkanoates from mixed microbial cultures using microwave-assisted extraction
Bocaz-Beltran, Jorge
Rocha, Sebastian
Pinto-Ibieta, Fernanda
Ciudad, Gustavo
Cea, Mara
JOURNAL OF CHEMICAL TECHNOLOGY AND BIOTECHNOLOGY, 2021, 96 (09) : 2596 - 2603
[4] Production and Characterization of Polyhydroxyalkanoates from Wastewater via Mixed Microbial Cultures and Microalgae
Bagatella, Simone
Ciapponi, Riccardo
Ficara, Elena
Frison, Nicola
Turri, Stefano
SUSTAINABILITY, 2022, 14 (06)
[5] A review on microbes mediated resource recovery and bioplastic (polyhydroxyalkanoates) production from wastewater
Ahuja, Vishal
Singh, Pankaj Kumar
Mahata, Chandan
Jeon, Jong-Min
Kumar, Gopalakrishnan
Yang, Yung-Hun
Bhatia, Shashi Kant
MICROBIAL CELL FACTORIES, 2024, 23 (01)
[6] Optimization of Green Extraction and Purification of PHA Produced by Mixed Microbial Cultures from Sludge
Reis, Guilherme A. de Souza
Michels, Michiel H. A.
Fajardo, Gabriela L.
Lamot, Ischa
de Best, Jappe H.
WATER, 2020, 12 (04)
[7] Polyhydroxyalkanoates (PHA) production from fermented thermal-hydrolyzed sludge by mixed microbial cultures: The link between phosphorus and PHA yields
Tu, Weiming
Zhang, Dandan
Wang, Hui
WASTE MANAGEMENT, 2019, 96 : 149 - 157
[8] Improvement of the Polyhydroxyalkanoates Recovery from Mixed Microbial Cultures Using Sodium Hypochlorite Pre-Treatment Coupled with Solvent Extraction
Montiel-Jarillo, Gabriela
Morales-Urrea, Diego A.
Contreras, Edgardo M.
Lopez-Cordoba, Alex
Yesid Gomez-Pachon, Edwin
Carrera, Julian
Eugenia Suarez-Ojeda, Maria
POLYMERS, 2022, 14 (19)
[9] A new method of polyhydroxyalkanoates production by mixed microbial cultures
Pokoj, T.
Klimiuk, E.
Gusiatin, Z.
Kulikowska, D.
NEW BIOTECHNOLOGY, 2009, 25 : S259 - S260
[10] Modeling polyhydroxyalkanoates production from sugarcane vinasse by mixed microbial cultures
Rezende, E. G. F.
Oliveira, G. H. D.
Couto, P. T.
Zaiat, M.
Ribeiro, R.
JOURNAL OF WATER PROCESS ENGINEERING, 2023, 53

← 1 2 3 4 5 →