Physical properties of rice bran wax in bulk and organogels

被引：5
|
作者：
Dassanayake, Lakmali Samuditha K. [1 ]
Kodali, Dharma R. [2 ,3 ]
Ueno, S. [1 ]
Sato, K. [1 ]
机构：
[1] Laboratory of Food Biophysics, Graduate School of Biosphere Science, Hiroshima University, Kagamiyama 1-4-4, Hiroshima 739-8528, Japan
[2] Global Agritech Inc., 710 Olive Ln, Minneapolis, MN 55447, United States
[3] Department of Bioproducts and Biosystems Engineering, University of Minnesota, 1390 Eckles Avenue, St Paul, MN 55108, United States
来源：
JAOCS, Journal of the American Oil Chemists' Society | 2009年 / 86卷 / 12期
关键词：
Differential scanning calorimetry (DSC); optical microscopy; and X-ray diffraction (XRD) were used to examine the thermal behavior; crystal structure; and crystal morphology of rice bran wax (RBX) in bulk and oil-wax mixtures; and to compare them with those of carnauba wax (CRX) and candellila wax (CLX). The RBX employed in the present study was separated from rice bran oil by winterization; filtration; refinement; bleaching; and deodorization. The RBX crystals melted in the bulk state at 77-79 °C with ΔH melting = 190.5 J/g; which is quite large compared with CLX (129 J/g) and CRX (137.6 J/g). XRD data of the RBX crystals revealed O⊥ subcell packing and a long spacing value of 6.9 nm. Thin long needle-shaped crystals were observed in the mixtures of RBX and liquid oils [olive oil and salad oil (canola:soy bean oil = 50:50); therefore; the dispersion of RBX crystals in these liquid oils was much finer than that of CRX and CLX crystals. Organogels formed when the mixture of every plant wax and liquid oil was melted at elevated temperature and cooled to ambient temperature. However; the mixture of RBX and olive oil at a concentration ratio of 1:99 wt.% formed an organogel at 20 °C; whereas the lowest concentration necessary for CRX to form an organogel in olive oil was 4 wt.% and that for CLX was 2 wt.%. Observation of the rate of gel formation using DSC and viscosity measurements indicated that the gel structure formed soon after RBX crystallized; whereas a time delay was observed between the organogel formation and wax crystallization of CRX and CLX. These results demonstrate RBX's good organogel-forming properties; mostly because of its fine dispersion of long needle like crystals in liquid oil phases. © 2009 AOCS;
D O I：
暂无
中图分类号：
学科分类号：
摘要：
Journal article (JA)
引用
收藏
页码：1163 / 1173
相关论文
共 50 条
  • [1] Physical Properties of Rice Bran Wax in Bulk and Organogels
    Dassanayake, Lakmali Samuditha K.
    Kodali, Dharma R.
    Ueno, S.
    Sato, K.
    JOURNAL OF THE AMERICAN OIL CHEMISTS SOCIETY, 2009, 86 (12) : 1163 - 1173
  • [2] Crystallization Kinetics of Organogels Prepared by Rice Bran Wax and Vegetable Oils
    Dassanayake, Lakmali Samuditha K.
    Kodali, Dharma R.
    Ueno, Satoru
    Sato, Kiyotaka
    JOURNAL OF OLEO SCIENCE, 2012, 61 (01) : 1 - 9
  • [3] Influence of bleached rice bran wax on the physicochemical properties of organogels and water-in-oil emulsions
    Pandolsook, Sawanya
    Kupongsak, Sasikan
    JOURNAL OF FOOD ENGINEERING, 2017, 214 : 182 - 192
  • [4] Storage stability of bleached rice bran wax organogels and water-in-oil emulsions
    Pandolsook, Sawanya
    Kupongsak, Sasikan
    JOURNAL OF FOOD MEASUREMENT AND CHARACTERIZATION, 2019, 13 (01) : 431 - 443
  • [5] Storage stability of bleached rice bran wax organogels and water-in-oil emulsions
    Sawanya Pandolsook
    Sasikan Kupongsak
    Journal of Food Measurement and Characterization, 2019, 13 : 431 - 443
  • [6] WAX LIPID IN RICE BRAN
    ITO, S
    SUZUKI, T
    FUJINO, Y
    CEREAL CHEMISTRY, 1983, 60 (03) : 252 - 253
  • [7] WAX LIPID IN RICE BRAN
    ITO, S
    SUZUKI, T
    FUJINO, Y
    JOURNAL OF THE AGRICULTURAL CHEMICAL SOCIETY OF JAPAN, 1981, 55 (03): : 247 - 253
  • [8] EFFECT OF WAX CONTENT ON FLOW PROPERTIES OF RICE BRAN OIL
    RAMAKRISHNA, P
    VENKATESH, KVL
    POORNIMA, TC
    MANOHAR, B
    JOURNAL OF THE AMERICAN OIL CHEMISTS SOCIETY, 1987, 64 (06) : 859 - 861
  • [9] Utilization and Evaluation of Rice Bran and Rice Bran Wax as a Tablet Lubricant
    Kittipongpatana, Ornanong S.
    Trisopon, Karnkamol
    Wattanaarsakit, Phanphen
    Kittipongpatana, Nisit
    PHARMACEUTICS, 2024, 16 (03)
  • [10] Effect of vegetable oil unsaturation and minor polar components on the physical properties of rice bran wax oleogels
    Hwang, Hong-Sik
    Kim, Sanghoon
    Winkler-Moser, Jill K.
    Liu, Sean X.
    JOURNAL OF FOOD SCIENCE, 2025, 90 (01)
12345