Performance experiment of dust removal and waste heat resources recovery of mine ventilation

被引：0
|
作者：
Tang X.-M. [1 ]
Ma S.-X. [1 ]
Duan Z.-M. [2 ]
机构：
[1] School of Electrical and Power Engineering, Taiyuan University of Technology, Taiyuan
[2] Taiyuan Coal Gasification(Group) Corporation, Limited, Taiyuan
来源：
Ma, Su-Xia (msx02@mails.tsinghua.edu.cn) | 1984年 / China Coal Society卷 / 41期
关键词：
Dust removal efficiency; Heat exchange efficiency; Mine ventilation air; Multi-stage spray chamber; Waste heat utilization;
D O I：
10.13225/j.cnki.jccs.2016.0047
中图分类号：
学科分类号：
摘要：
Coal mining process will produce a huge amount of low temperature heat sources. It does help to achieve the purpose of environment protection and energy saving if the waste energy can be used legitimately. The waste heat recovery and purification system of mine ventilation was designed to recover sensible heat and remove the dust in the mine ventilation system by using multi-stage spray chamber. In this paper, the heat transfer efficiency and the dust removal efficiency at various stages were studied experimentally, and the influence factors were analyzed. The results show that after adopting two-stage spray chamber, the temperature of return water increases about 3.4℃, and the total heat exchange efficiency is 82.72%, when all other parameters remain constant, namely the overall mass flow ratio of water to wind remains 0.649 8, the single stage mass flow ratio of water to wind remains 0.324 and environmental temperature is 17℃. With the increase of air temperature and humidity, the heat transfer efficiency at all levels increases which is not obvious when the humidity exceeds 70%. The heat exchange efficiency decreases and the removal efficiency reduces with the increase of air velocity. The heat exchange efficiency reduces as the inlet water temperature of the spray chamber increases. When the air velocity is 1 m/s, the removal efficiency is 55%. © 2016, Editorial Office of Journal of China Coal Society. All right reserved.
引用
收藏
页码：1984 / 1988
页数：4
相关论文
共 11 条
  • [1] Liu J., Study and application of mine low temperature thermal resources utilization technology, Coal Science and Technology, 41, 4, pp. 124-128, (2013)
  • [2] Du C., Dong Z., Meng G., Et al., Influence factor research on water saving and heat exchange efficiency of spraying heat exchanger in mine air return roadway, Coal Science and Technology, 40, 12, pp. 80-83, (2012)
  • [3] Du C., Zhang J., Wang R., Simulative and experimental study on impact factors on heat transfer performance of mine return air heat exchanger, Journal of China Coal Society, 39, 5, pp. 897-902, (2014)
  • [4] Xu G., Heat energy utilization technology and its application of mine return air, Zhongzhou Coal, 7, pp. 87-89, (2011)
  • [5] Duan Z., Ma S., Guo Q., Mine waste heat resources utilization technology, Safety in Coal Mine, 45, 9, pp. 68-71, (2014)
  • [6] Ji X., Diao N., Sun X., Et al., Full recovery of waste heat resources in mine ventilation based on water-source heat pump technology, Heating, Ventilating and Air Conditioning, 12, pp. 8-10, (2010)
  • [7] Mao J., Chen F., Geng S., Discussion on utilization of mine return air resources, Mining Safety and Environmental Protection, 42, 2, pp. 100-103, (2015)
  • [8] Li S., Qian X., Zhao H., Verifying and revising on the law of the heat and mass transfer in high speed air-washer, Fluid Mechinery, 42, 7, pp. 78-83, (2014)
  • [9] Ma H., Liu Z., Experimental study of heat and moisture transfer process in the air conditioning spray chamber, Journal of Shenyang Institute of Engineering(Natural Science), 39, 3, pp. 232-233, (2007)
  • [10] Cui H., Wang H., Chen S., Parameters optimization and theoretical model of heat-mass transfer in a spray heat exchanger attaching to a main fan diffuser, Journal of China Coal Society, 39, 10, pp. 2047-2052, (2014)
12