GROWTH, METABOLIC, AND ANTIBODY-PRODUCTION KINETICS OF HYBRIDOMA CELL-CULTURE .2. EFFECTS OF SERUM CONCENTRATION, DISSOLVED-OXYGEN CONCENTRATION, AND MEDIUM PH IN A BATCH REACTOR

The effects of serum, dissolved oxygen (DO) concentration, and medium pH on hybridoma cell physiology were examined in a controlled batch bioreactor using a murine hybridoma cell line (167.4G5.3). The effect of serum was also studied for a second murine hybridoma cell line (S3H5/gamma-2bA). Cell growth, viability, cell density, carbohydrate and amino acid metabolism, respiration and energy production rates, and antibody production rates were studied. Cell growth was enhanced and cell death was decreased by increasing the serum level. The growth rates followed a Monod-type model with serum being the limiting component. Specific glucose, glutamine, and oxygen uptake rates and specific lactate and ammonia production rates did not change with serum concentrations. Amino acid metabolism was slightly influenced by the serum level. Cell growth rates were not influenced by DO between 20% and 80% air saturation, while the specific death rates were lowest at 20-50% air saturation. Glucose and glutamine uptake rates increased at DO above 10% and below 5% air saturation. Cell growth rate was optimal at pH 7.2. Glucose and glutamine uptake rates, as well as lactate and ammonia production rates, increased above pH 7.2. Metabolic rates for glutamine and ammonia were also higher below pH 7.2. The consumption or production rates of amino acids followed the glutamine consumption very closely. Cell-specific oxygen uptake rate was insensitive to the levels of serum, DO, and pH. Theoretical calculations based on experimentally determined uptake rates indicated that the ATP production rates did not change significantly with serum and DO while it increased continually with increasing pH. The oxidative phosphorylation accounted for about 60% of total energy production. This contribution, however, increased at low pH values to 76%. The specific antibody production rate was not growth associated and was independent of serum and DO concentrations and medium pH above 7.20. A 2-fold increase in specific antibody production rates was observed at pH values below 7.2. Higher concentrations of antibody were obtained at high serum levels, between 20% and 40% DO, and at pH 7.20 due to higher viable cell numbers obtained.